孙秀魁
,
陈文绣
,
徐坚
,
范学书
,
魏文铎
,
吴玉琨
,
彭应国
金属学报
本工作采用惰性气体蒸发法制备Al超微粒子,采用高分辨透射电子显微镜,X射线衍射和X光电子谱等多种分析技术,详细研究了Al超微粒子的结晶形态、晶体结构、表面状态和组成,结果指出,在高纯惰性气氛中制备的Al超微粒子具有明显的结晶形态,大部分粒子为一单晶体,晶体结构为fcc,α_0=0.405nm,结果还发现,Al超微粒子表面存在一层非晶Al_2O_3,平均厚约2nm,对粒子本身具有很好的保护作用,因此,用惰性气体蒸发法制备的Al超微粒子在空气中是相当稳定的。
关键词:
Al超微粒子
,
structure
,
surface condition
,
amorphous alumina
张寒露
,
范育京
,
唐聿明
,
曹京宜
,
左禹
腐蚀科学与防护技术
doi:10.11903/1002.6495.2015.389
利用加速腐蚀实验、附着力测试、红外光谱分析等手段,研究了几种典型涂层与环氧玻璃钢底材的附着力及其影响因素.玻璃钢与环氧涂层的附着力与玻璃钢表面的粗糙度和润湿性能有关,当玻璃纤维布外露时,涂层附着力最高;240#砂纸打磨底材后涂层附着力高于60#及600#砂纸打磨底材的涂层附着力.不同涂层在玻璃钢表面的附着力与涂层中主要官能团的极性有关,含有极性较强的多卤素键的氟碳树脂漆表现出较强的附着力;与环氧涂层相比,聚氨酯涂层和聚硅氧烷涂层除含有与环氧涂层相同的酯键、醚键外,还因含有氨酯键、硅氧键等极性键,显示出较高的附着力.对比40℃浸泡实验、盐雾实验和湿热实验的结果,40℃浸泡实验对涂层附着力降低的影响更大;红外光谱分析表明,40℃浸泡与盐雾实验相比涂层内部的分子降解程度更明显.
关键词:
玻璃钢
,
涂层
,
附着力
,
表面状态
,
腐蚀环境
SUN Xiukui CHEN Wenxiu XU Jian FAN Xueshu WEI Wenduo State Key Laboratory of Rapidly Solidified Non-Equilibrium Alloys
,
Institute of Metal Research
,
Academia Sinica
,
Shenyang
,
ChinaWU Yukun PENG Yingguo Laboratory of Atomic Imaging of Solids
,
Institute of Metal Research
,
Academia Sinica
,
Shenyang
,
China Associate Professor
,
Institute of Metal Research
,
Academia Sinica
,
Shenyang 110015
,
China
金属学报(英文版)
The crystal habit,crystalline structure,surface condition and composition of the ultrafine Al particles prepared by inert gas evaporation method were studied in detail by means of high resolution transmission electron microscope,X-ray diffraction and X-ray photo-electron spectrum.The results indicate that the ultrafine Al particles prepared in high pure inert gas are of clear crystal habits,single crystal in a large majority and fcc crystalline structure with a_0=0.405 nm.It is also found on the surface of the Al particles that there is a layer of amor- phous Al_2O_3 with 2 nm average thickness,which could protect the particles against oxidizing further.Therefore,the ultrafine Al particles prepared by the inert gas evaporation method are very stable in atmosphere.
关键词:
ultrafine Al particle
,
null
,
null
,
null
